Managing Mine Tailings To Protect Scarce Water Supply

Managing Mine Tailings To Protect Scarce Water Supply

Candelaria, Chile




Location: Candelaria, Chile


Pollutant: Copper mine tailings


Cause: Open pit mining and mineral processing activities could contaminate limited water sources in the desert.


Health Impact: Tailing slurries with toxic components (such as cyanide) would contaminate groundwater from limited existing sources and cause nervous ad immune system damages.


Output: A tailing impoundment/cut-off wall system was constructed to dispose of tailings and conserve scarce water in the desert region. 80 percent of the water bound up in the tailings is treated and recirculated into the supply system.


Outcome: The multi-stage treatment process ensures trapping of tailings with toxic chemical content such as cyanide. The system, as a whole, collects around 365 million tons of tailings and treats the water content found in these materials.


Implications: Successful design and implementation of this comprehensive system serves as a prime example for tailings management in development countries, which is one of the most severe and underestimated environmental and health issues.


Remaining Challenges: Extract and treat the last 20 percent of water bound up in the tailings.




As mentioned in the 2008 Report, mine tailings are the waste materials after the minerals are separated from the ore in a mineral processing plant. "Typically, the original rock is crushed or ground to a particle size of less than 0.1 mm in order to release the valuable constituents."[1] They typically contain the valuable constituents in low concentrations, unrecovered by the process, and may also contain toxic residues of chemicals used in the separation process. Water is used as a binding agent in the impoundment process to extract the valuable mineral constituents. Supernatant water, once released into the environment, would change the current pH and heavy metal content of groundwater supply. Cyanide, which damages the brain and the heart, is commonly found in mine tailings. The U.S. EPA identified cyanide in at least 471 of the 1,662 National Priorities Listed sites for pollution remediation under Superfund.




The Candelaria Copper Mine is located in the Sierra El Bronce mountain range in the Copiapó River valley approximately 20 km southwest of Copiapó in the Atacama region of Chile. At a 600-m elevation, this mine has an estimated life of 20 years. Although biodiversity is relatively low in this desert environment, its scarce water resources are integral to agricultural irrigation, urban residential and commercial, and industrial purposes. Mining is the most significant source of economic profit for the region, followed by agriculture and small-scale industry such as copper refinery.1




The U.S. Center for Disease Control and Prevention (CDC) states shortness of breath, seizures, and loss of consciousness as the early indications of cyanide poisoning. Short-term exposure causes brain damage and coma. Miners exposed to high levels of heavy metals could experience breathing difficulties, chest pains, vomiting, headaches, and enlargement of thyroid glands.




The United Nations Environmental Programme (UNEP) and the International Council on Metal and the Environment (ICME) report on tailings management cited exposure pathways include being in contact with tailings transported by wind and water erosion and consuming ground and surface water contaminated by toxins including cyanide, sulfates, or other dissolved metals.




The Candelaria project focused on proper disposal of tailings with impoundment technology as well as effluent leakage prevention. A baseline study was conducted to determine the content and extent of tailings Effluent with tailings content is trapped by spill collection systems and a temporary containment pond and re-circulated back to the processing facility for treatment. This facility thickens tailings to 50 percent solids content for easier disposal. "The major component of the 450-hectare tailings disposal facility is the dam constructed of mine waste material." Construction of this dam is divided into multiple stages to comprehensively trap and filter tailings from the water. This tailing impoundment/cut-off wall system was designed to contain more than 365 million tons of tailings combined and prevent storm surge with tailings content from entering the water treatment system. As a result, water pollution is prevented and through the recycling process, the quantity of limited ground and surface water supplies are preserved in this desert environment




The Compañia Contractual Minera Candelaria (CCM Candelaria)-a former joint venture of Phelps Dodge Corporation of the USA and Sumitomo Metal Corporation of Japan, currently owned by Freeport-McMoRan Copper & Gold, Inc.




Treatment systems similar to the one installed at the Candelaria copper mine are able to extract and treat a majority of the water locked up in tailings. The remaining 20 percent of water bound up in tailings is generally difficult to remove. Additionally, design of the tailings disposal/water treatment structure must be able to confine the smaller particles of tailings, as leakage of these toxic materials could yield negative environmental and health impacts.




To top

Green Cross
Schweiz | Suisse | Svizzera
Mühlebachstrasse 32
Postfach 769
8024 Zürich
Tel. +41 (0)43 499 13 23

Spendenkonto Green Cross Schweiz:
PC 80-576-7
IBAN CH02 0900 0000 8000 0576 7